PERFORMANCE GUIDE
|
FILM PROPERTIES
Chemical Resistance
Chemical Resistance
Water Resistance
|
Not recommended where spillage of solvents is likely.
Good
Good
|
THEORECTICAL COVERAGE
|
A guide to the theoretical coverage which can be achieved under normal conditions is 9m²/L.
|
PRODUCT DATA
|
COMPOSITION
(nominal)
|
Pigment : Lightfast Pigments and Mineral extenders.
(Glass Beads in the case of reflective versions.)
Blinder : Modified Epoxy Ester.
Solvent : Aromatic Hydrocarbon.
|
VOLUME SOLIDS
|
60% (nominal).
|
FLASH POINT
|
Below 22°C.
|
APPLICATION
|
THINNING
Brush or Roller
Road Marking Machine
|
For normal use, thinning is usually not necessary. If required, add up to 1 part of Dulux Thinner 850 - 11 to 10 parts of paint (10%).
Add up to 1 part of Dulux Thinner 850 - 11 to 10 parts of paint (10%).
|
DRYING TIMES
Touch Dry
Recoat
|
Single coat at standard thickness:
Normally touch dry after 15 minutes and resistant to vehicular traffic after 30 - 45 minutes.
After 30 minutes.
|
CLEANING UP
|
Clean all equipment with Dulux Thinner 850 - 11 immediately after use.
|
PRE - APPLICATION
|
SURFACE PREPARATION
|
Surfaces must be sound, clean, dry, free from all defective or poorly adhering material, dirt, grease etc.
Due to the variably of asphalt, newly laid bitumen based surfaces (up to six months old) will need to be sealed with a coat of emulsion paint or shellac knotting, in order to prevent bleeding. A test area is recommended before work is commenced.
|
SYSTEM INFORMATION
Powdery Surfaces
|
PRIMER (1 COAT)
No Primer Required.
|
FINISH (2 COATS)
Dulux Pearl Glo Emulsion (A913)
|
|
PRECAUTION
|
SAFETY, HEALTHY AND ENVIRONMENTAL INFORMATION
|
In case of contact with eyes, rinse immediately with plenty of water and seek medical advice.
To remove splashes of paint from skin, use soap and water or a recognised cleanser.
Keep away from food, drinks, animal feed and out of the reach of children.
Container must be stored in a cool and shaded place.
It must be tightly closed in a secure, upright position.
Work in a well-ventilated area and do not breathe in vapour or spray.
A suitable mask should be worn during sanding.
When applying paint, it is advisable to wear eye protection and suitable gloves.
In case of a spillage, contain and collect spillage using sand or earth and do not empty into watercourses, drains or the environment.
Dispose of any paint waste in accordance with the appropriate Environmental Quality Regulations.
Refer to Dulux Product Safety Data Sheet for further details.
In case of emergency, refer to Emergency Incident Response Hotline 1800 80 6187.
|
|
     
|
